You are on page 1of 19

DESIGN AND FABRICATION

OF REMOTE CONTROLLED
PROJECT GUIDE:SCISSOR JACK S.RAMA RAO
,
Dept.ofMechanicalEngg

SVCET.

PROJECT MEMBERS:D.SAI CHAITHANYA REDDY (10781A0321)


D.RAJA PRASANNA KUMAR (10781A0323)
THRINADH EMMIDI
(10781A0325)
G.DINESH KUMAR
(10781A0327)

M.Tech

INTRODUCTION
The remote controlled scissor jack is a
modified form of conventional scissor jack that
helps to lift the load using motor as a source
of energy and gear box to control the lift of
the jack.
A scissor jack is operated by turning a lead
screw. The height of the jack is adjusted by
turning the lead screw. This can be done
either manually or by integrating an electric
motor with it. This integration is our project.

BLOCK DIAGRAM:-

POWER
SUPPLY
SCISSOR
JACK
MICROCONTROLL
ER

REMOTE
SENSOR
CONTROLLER
RECEIVER

MOTOR

REMOTE
TRANSMITTER
POWER SUPPLY

PARTS:
SCISSOR JACK
DC MOTOR
GEARS
TRANSMITTER
RECEIVER

STEPS TO BE PERFORMED
Design of scissor jack by considering
all real time values.
As per load specification making of
gears
Motor attachment for gears
Base plate arrangement
Connection of receiver and
transmitter for DC motor

SCISSOR JACK

MOTOR
SPECIFICATIONS:

MOTOR

CURRENT: 10 amp
VOLTAGE: 12 V
SPEED : 1200 rpm

GEARS

CIRCUIT BOARD

REMOTE CONTROLLER

BATTERY CONNECTOR

DC MOTOR CONNECTOR

SCISSOR JACK BASE PLATE WELDING

ASSEMBLED SCISSOR JACK

ARRANGEMENT OF SCISSOR JACK


UNDER THE VEHICLE

SCISSOR JACK AT MAXIMUM RAISED


POSITION

CONCLUSION
Scissor Jacks are the ideal product to push, pull, lift, lower and position loads of
anything from a couple of kilograms to hundreds of tonnes. The need has long
existed for an improved portable jack for automotive vehicles.
It is highly desirable that a jack become available that can be operated
alternatively from inside the vehicle or from a location of safety off the road on
which the vehicle is located. Such a jack should desirably be light enough and
be compact enough so that it can be stored in an automobile trunk, can be lifted
up and carried by most adults to its position of use, and yet be capable of lifting
a wheel of a 500-1,000 kg vehicle off the ground.
Further, it should be stable and easily controllable by a switch so that jacking
can be done from a position of safety. It should be easily movable either to a
position underneath the axle of the vehicle or some other reinforced support
surface designed to be engaged by a jack.
Thus, the product has been developed considering all the above requirements.
This particular design of the motorized scissor jack will prove to be beneficial in
lifting and lowering of loads.

Thank you

You might also like