You are on page 1of 32

Reserves Estimation and Classification

5/29/2012

Introduction

Field reservoir engineer is responsible for the estimation and classification of reserves.
Estimation techniques: material balance calculations sweep efficiency analysis decline curve analysis reservoir simulation All reserves estimates involve some degree of uncertainty.
2

5/29/2012

Why Reserve Estimates?

Measure effectiveness of exploration and development. Budgeting for drilling and facilities. Unitization. Purchase / sale of properties. Bank loans. Taxation. Government policy and planning.
3

5/29/2012

Definition

Reserves are estimated quantities of crude oil, condensate, natural gas, natural gas liquids, and associated substances anticipated to be commercially recoverable:
- from known accumulations, - under existing or anticipated economic conditions, - by established operating practices, and - under current or anticipated government regulations.
4

5/29/2012

Original Oil and Gas In place Calculation

Volumetric

OOIP or OGIP = (Rock Volume) x (Porosity) x (1 Water Saturation)/ ( Formation Volume Factor )

5/29/2012

Original Oil and Gas In place Calculation

Material Balance
Expanded volume of Volume volume of = withdrawals - of original injected reservoir fluids fluids

5/29/2012

Recovery and Efficiency Calculations

Recovery factors : STB/acre-ft and MCF/acre-ft Recover efficiencies: fractional recovery of OOIP or OGIP Methods of estimation:
- analogies - correlations - water flood design charts - material balance programs - reservoir simulation
7

5/29/2012

Analogy Method

The analogous reservoirs should be similar to: . Drive mechanism . Permeability and porosity . Well spacing and pattern . Size . Relative volumes of oil, gas and aquifer . Degree of permeability and porosity heterogeneity . Net-to-gross sand ratio . Production practices . Depositional environment and trapping mechanism . PVT properties
Recovery factor adjustments are made to compensate for differences between the analogous reservoirs and the reservoirs being evaluated.

5/29/2012

Correlations

Depletion Drive Gas Reservoirs: Rec. Efficiency =1 - Pa Zi / Pi Za


Depletion Drive Oil Reservoirs: 1.During under saturated stage: Rec. Efficiency = Ce(Pi-Pb)Boi/Bob Where: Ce=(SoCo+SwCw+Cp)/So 2. During saturated stage: Er = 0.41815 ( (1-Sw)/Bob) x (k/1000ob)(Sw)(Pb/Pa) Water Drive Gas Reservoir: Er=(1-PaZi/PiZa) + ((PaZi/PiZa) EvEd) Where: Ed=(1-Swi-Sgr)(1-Swi) Sgr= 0.62 -1.3

5/29/2012

Waterfloods

Mobility Ratio M = (Krw/w) x (Kro/o) Recovery Efficiency Er = Ea x (Swb Swi)/(1-Swi) Areal sweep efficiency, Ea, from a homogenous 5-spot water flood for a certain M can be obtained from charts.
10

5/29/2012

Ultimate Recovery

Volumetric with Recovery Efficiency: Ultimate Recovery = Er x OOIP or OGIP( from volumetric)
Material Balance with Recovery Efficiency: Ultimate Recovery = Er x OOIP or OGIP( from material balance)

5/29/2012

11

Decline Curve Analysis

Ultimate recovery is the sum of cumulative recovery to date and remaining reserves. Remaining reserves can be calculated with decline curve analysis.

5/29/2012

12

Reservoir Simulation

Reservoir simulation incorporates a comprehensive application of physical laws governing multiphase fluid flow in porous media.
Reservoir simulation can be summarized in three-step process: 1. Setting up mathematical equations that describe fluid flow. 2. Solving the Mathematical equations. 3. Setting up the numerical model.
13

5/29/2012

Reserves Classification

Reserves are estimated quantities of crude oil, condensate, natural gas, natural gas liquids, and associated substances anticipated to be commercially recoverable:
- from known accumulations, - under existing or anticipated economic conditions, - by established operating practices, and - under current or anticipated government regulations
Dr.Helmy Sayyouh

5/29/2012

14

Reserves Classification

All reserves estimates involve some degree of uncertainty, depending on : The amount and reliability of geologic and engineering data available at the time of the estimates. Interpretation of these data

5/29/2012

15

Milestones in Reserves Definitions

1944: Frederic Lahee ( API ) 1955: Frederic Lahee ( WPC ) 1960: American Petroleum Institute 1962: Jan Arps ( SPE ) 1965: SPE 1972: V .E. Mckelvey (USGSurvey) 1981: SPE 1985: SPE 1987: SPE World Petroleum Congress(WPC)
Dr.Helmy Sayyouh

5/29/2012

16

SPE-Endorsed Definitions of Reserves

Reserves in General 1. Known or discovered accumulations. 2. Estimated volumes: crude oil condensate natural gas natural gas liquids associated substances such as sulfur and carbon dioxide. 3. Based on interpretation of geologic and engineering data. 4. Commercially recoverable under economic, operating and regulating condition. 5. Time dependent ( production ). 6. Involve degree of uncertainty. 7. Subject to revision.
17

5/29/2012

Methods of Classifying Reserves

1. Ownership: Total Gross Net 2. Recovery Mechanism: Primary - Improved 3. Degree of Uncertainty: Proved Probable Possible 4. Development Status: Developed Undeveloped 5. Productive Status: Producing Non-producing
18

5/29/2012

Ultimate Potential

Ultimate Recovery

Future Additions

Cumulative Production

Reserves

Proved Reserves

Unproved Reserves

5/29/2012

Proved Developed

Proved Undeveloped

Probable Reserves

Possible Reserves
19

Proved Reserves

Proved oil and gas reserves are the estimated quantities of crude oil, natural gas, and natural gas liquids which can be recoverable:
- in future years - from known reservoirs - under exiting economic and operating conditions. A confidence level of 90 to 100% is required.
20

5/29/2012

Proved Reserves

Proved reserves must have:


The area of a reservoir which includes - that portion delineated by drilling and defined by GOC and / or OWC - the adjoining portions not yet drilled but economically productive The facilities to process .
21

5/29/2012

Proved Reserves

Proved reserves have been divided into: Proved Developed Reserves: are expected to be recovered through exiting wells with exiting equipment and operating methods. Proved Undeveloped Reserves: are expected to be recovered from new wells on undrilled acreage or from exiting wells where a major expenditure is require for recompletion.
22

5/29/2012

Probable Reserves

Probable reserves are less certain than proved reserves and they are more likely to be recovered than not under mid-trend economic conditions. A confidence level of 50 to 90% is required.
Probable reserves have been divided to: Class 1 : Reserves representing the primary recovery from the delineated area of a known reservoir.

5/29/2012

23

Probable Reserves

Class 2: Reserves representing the primary recovery which depends on: a. Lateral extension of the reservoir beyond the limits assumed for proved or probable class 1 reserves due to up dip or down dip extensions. b. Undrilled fault blocks adjacent to the delineated area of a known reservoir. c. Direct or diagonal offsets to spacing units having proved or probable class1 reserves.

5/29/2012

24

Probable Reserves

Class 3 : Reserves representing the primary recovery dependent upon the development of new reservoirs ( not yet produced or tested ) within the area of assigned proved reserves. Class 3 reserves occur in a new reservoir overlying or underlying a proved reservoir.

5/29/2012

25

Probable Reserves

Class 4 : Incremental reserves where an alternate interpretation of actual or anticipated performance or volumetric data indicates more reserves than can be classified as proved or probable class1 to 3.
Class 5 : Additional quantities likely to be recoverable through the application, expansion or modification of improved recovery techniques.
26

5/29/2012

Possible Reserves

Possible reserves are less certain than probable reserves and can be estimated with a low degree of certainty. Insufficient to indicate whether they are more likely to be recovered than not under high-trend economic conditions. A confidence level of 20 to 50% is required. Possible reserves have been divided to: Class 1 : Reserves representing the primary recovery from the delineated area of a known reservoir.
27

5/29/2012

Possible Reserves

Class 2: Reserves representing the primary recovery which depends on: a. Lateral extension of the reservoir beyond the limits assumed for proved or probable class 1 reserves due to up dip or down dip extensions. b. Undrilled fault blocks adjacent to the delineated area of a known reservoir. c. Direct or diagonal offsets to spacing units having proved or probable class1 reserves
28

5/29/2012

Possible Reserves

Class 3 : Reserves representing the primary recovery dependent upon the development of new reservoirs ( not yet produced or tested ) within the area of assigned proved reserves. Class 3 reserves occur in a new reservoir overlying or underlying a proved reservoir.

5/29/2012

29

Possible Reserves

Class 4 : Incremental reserves where an alternate interpretation of actual or anticipated performance or volumetric data indicates more reserves than can be classified as proved or probable class1 to 3.
Class 5 : Additional quantities likely to be recoverable through the application, expansion or modification of improved recovery techniques.
30

5/29/2012

Problems in Reserve Classification

Frontier Areas 1. No analogous reservoirs. 2. Sparse subsurface control. 3. Remote from market. 4. High operating costs.
Heavy and Extra Heavy Crude Thermal stimulation is required and its response is highly variable.
Dr.Helmy Sayyouh

5/29/2012

31

Possible Future Development in Reserve Classification

Matrix to describe geologic uncertainty and feasibility of commercial extraction. Inclusion with reserves of geologic and engineering bases for estimate Quantification of probabilities associated with reserve classifications.

5/29/2012

32

You might also like